R.H. Peterson G46-18P Bedienungshandbuch PDF herunterladen

L-A2-256

Rev 6 - 1501210930

Important: Read these instructions carefully

before starting installation of the

burner control system.

Robert H. Peterson Co. • 14724 East Proctor Avenue • City of Industry, California 91746

INSTALLATION &

OWNER’S MANUAL

The Peterson Real-Fyre

burner system is to be

installed only in a solid-fuel-burning ﬁ replace with a

working ﬂ ue constructed of noncombustible material.

Solid fuels shall not be burned in a ﬁ replace where the

unit is installed. The installation, including provisions

for combustion, ventilation air, and required minimum

permanent vent opening, must conform with the

National Fuel Gas Code (ANSI Z223.1/NFPA 54)

and applicable local building codes. In Canada, the

installation must conform with the Natural Gas and

Propane Storage and Handling Installation Code

(CSA-B-149.1). A damper stop clamp is included to

maintain the minimum permanent vent opening and to

prevent full closure of the damper blade. The chimney

damper must be ﬁ xed fully opened when burning

the unit. The burner system is designed to burn

with yellow ﬂ ames; thus, adequate ventilation is

absolutely necessary.

INSTALLER & CONSUMER

These instructions MUST be

retained with this appliance

APK-17 PILOT KITS

Do not store or use gasoline or other

ﬂ ammable vapors and liquids in the vicinity

of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS:

• Open a window.

• Do not try to light any appliance.

• Do not touch any electrical switch; do

not use any phone in the building.

• Immediately call the gas supplier from

a neighbor’s phone and follow the gas

supplier’s instructions.

• If you cannot reach the gas supplier,

call the ﬁ re department.

WARNING

If the information in this manual is not followed

exactly, a ﬁ re or explosion may result, causing

property damage, personal injury, or loss of life.

Installation and service must be

performed by an NFI Certiﬁ ed or other

qualiﬁ ed professional installer, service

agency, or the gas supplier.

AUTOMATIC REMOTE LIGHTING SAFETY PILOT SYSTEM

WITH VARIABLE FLAME-HEIGHT REMOTE

FOR NATURAL OR PROPANE GAS

FEATURES:

• CONTROL OPERATED ON/OFF •

• VARIABLE FLAME-HEIGHT REMOTE •

• VARIABLE FLAME HEIGHT CONTROL •

• STANDING PILOT •

SUITABLE FOR THE FOLLOWING BURNERS:

• PAN BURNERS (P-SERIES) •

• G4 SERIES BURNERS •

• G45 SERIES BURNERS •

Models:

APK-17(M)(P)

1 2 3 4 5 6 ... 13 14

Inhaltsverzeichnis

Seite 1 - WARNING

1L-A2-256Rev 6 - 1501210930Important: Read these instructions carefully before starting installation of the burner control system.Robert H. Peterson C

Seite 2 - TABLE OF CONTENTS

10LIGHTING INSTRUCTIONS - 17 SERIESFOR YOUR SAFETY READ BEFORE LIGHTINGWARNING: If you do not follow these instructions exactly, a ﬁ re or explosion

Seite 3 - SPECIFICATIONS

11LIGHTING INSTRUCTIONS - 17 SERIES (cont.)2. Locate the remote transmitter and press and hold the ON/HI button (see Fig. 11-1). The ignition sequen

Seite 4 - NOTES PAGE

12LIGHTING INSTRUCTIONS - 17 SERIES (cont.)SHUTTING DOWNMAIN BURNER ONLY (pilot will remain lit):For remote shut down, press and hold the LO/OFF butto

Seite 5 - APK-17 REPLACEMENT PARTS LIST

13TROUBLESHOOTINGPROBLEM CAUSE SOLUTION1. Pilot will not light a. Obstruction in pilot gas supply or pilot gas-supply line is kinkedb. Inadequate g

Seite 6 - INSTALLATION

14Robert H. Peterson Co. • 14724 East Proctor Avenue • City of Industry, CA 91746 Quality Check Date:_________________Leak Test: ________________ Bu

Seite 7 - INSTALLATION (Cont.)

2L-A2-256Rev 6 - 1501210930TABLE OF CONTENTSGETTING STARTEDIMPORTANT INFORMATION ...

Seite 8

3L-A2-256Rev 6 - 1501210930CHECK TO BE SURE THAT THE PROPER FUEL GAS IS BEING USED WITH THIS PILOT KIT.The installation, including provisions for comb

Seite 9

4L-A2-256Rev 6 - 1501210930NOTES PAGEPlease use this page to record any information that you may want to have at hand.

Seite 10 - REMOTE LIGHTING (if equipped)

5L-A2-256Rev 6 - 15012109304APK-17 REPLACEMENT PARTS LIST26Note: Photos not to scale31Item Description Part No. Qty.1.Control valve SV-37

Seite 11 - MANUAL LIGHTING

6L-A2-256Rev 6 - 1501210930This safety pilot system must be installed by a qualiﬁ ed professional service technician. Instructions must be followed ca

Seite 12 - PILOT BURNER CHECK/ADJUSTMENT

7L-A2-256Rev 6 - 1501210930FLAMEDIVERTERBRACKETBURNERPA N2 1/2REAR WALLBurner panFlame diverter bracket1-1/4"INSTALLATION (Cont.)INSTALL FLAME D

Seite 13 - TROUBLESHOOTING

8L-A2-256Rev 6 - 1501210930INSTALLATION (Cont.)CONNECT TO GAS SUPPLYTo connect the valve to the gas supply, the ﬂ ex connector kit and component parts

Seite 14 - WARRANTY

9L-A2-256Rev 6 - 1501210930INSTALLATION (Cont.)CONNECT REMOTE RECEIVER (if equipped)Note: Discard the black wires that come with the remote receiver.